THE EFFECT OF BAND ENGINEERING OF SEMICONDUCTORS AND OTHER FACTORS ON PHOTOCATALYIC DEGRADATION OF ORGANIC POLUTANTS, TOWARDS A SCALE OF PHOTOCATALYTIC EFFECTIVENESS: A MULTIFACTORIAL EQUATION FOR THE PHOTOCATALYIC EFFICENCE. A REVIEW

- Photocatalytic degradation,
- methylene blue,
- solid-state,
- nanostructured metal oxides
Copyright (c) 2024 SChQ

This work is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.
Abstract
The direct conversion of solar energy using a photocatalyst in a degradation of a pollutant reaction is a source of a sustainable and clean environment remediation.
In general, photocatalyst are semiconductors that possess valence and conduction bands. These energy bands permit the absorption of photon energy to excite electrons in the outer orbitals of the photocatalyst. Photoexcited electron and hole pairs can subsequently induce a reaction that degrade organic pollutant molecules. Photocatalyst degradation of pollutants is affected by the band level and crystallinity of the photocatalyst among others, therefore, band engineering using chemical modifications as particle size, morphology and physical as band gap could create photocatalyst suitable for the large-scale photodegradation of organic pollutant. In this Review, different factors of the photocatalyst obtained by solid-state, such as size, morphology, band gap and others are analyzed in the photocatalyst efficiency of the degradation of organic contaminant. This review involves binary metal oxide photocatalyst of the MxOy type, prepared from a solid-state route. The photocatalytic degradation of blue methylene using our the solid-state TiO2, Fe2O3, NiO, ReO3, IrO2, Rh2O3, Rh/RhO2, and the actinide ThO2 prepared nanostructured metal oxides by a solid state method is described and discussed. Also, other studies of photocatalysis also prepared in solid state for the degradation of methylene blue and reported in the literature are shown and analyzed. With regard the photocatalytic efficiency, factors such as the particle size and morphology, the crystalline phase and the pyrolysis temperature used in the solid-state preparation method are very important. A multifactorial equation that summarizes the main factors that govern the photocatalytic efficiency of a photocatalyst is proposed. A parameterization of these factors is discussed through an equation of the photocatalytic efficiency as a function of these parameters. The importance of each of these parameters/factors in the photocatalytic efficiency against methylene blue degradation is discussed.
References
- - Masciangoli, T.; Zhang, W. Environmental Technologies. Environ. Sci. Technol. 2003, 37, 102–108.
- Vaseashta, A.; Vaclavikova, M.; Vaseashta, S.; Gallios, G.; Roy, P.; Pummakarnchana, O. Nanostructures in environmental pollution detection, monitoring, and remediation. Sci. Technol. Adv. Mater. 2007, 8, 47–59.
- Khan, F.I.; Ghoshal, A.K. Removal of Volatile Organic Compounds from polluted air. J. Loss Prev. Process Ind. 2000, 13, 527–545.
- Allahveran, S. Mehrizad, A., Polyaniline/ZnS nanocomposite as a novel photocatalyst for removal of Rhodamine 6G from aqueous media: optimization of influential parameters by response surface methodology and kinetic modeling. J. Mol. Liq. 2017, 225, 339–346.
- - Rashi Gusain,R., Kanika Gupta K., Pratiksha Joshi P., Om P. Khatri P., Adsorptive removal and photocatalytic degradation of organic pollutants using metal oxides and their composites: A comprehensive review. Advances in Colloid and Interface Science (2019), 272, 102008.
- - Chan S.,H.,S., WuT., Joon Ching Juanb,J.C.-,Teh.C.Y., Recent developments of metal oxide semiconductors as photocatalysts in advanced oxidation processes (AOPs) for treatment of dye waste-water, J Chem Technol Biotechnol, 2011, 86, 1130–1158
- - Diaz,C., Valenzuela, M.L., Laguna-Bercero, M.A.Solid-State Preparation of Metal and Metal Oxides Nanostructures and Their Application in Environmental Remediation, Int. J. Mol. Sci. 2022, 23, 1093-1122.
- - Khan M.K., Abdullah Al-Mayouf A., Adil S.F., Metal oxides as photocatalyst, Journal of Saudi Chemical Society, 2015 19, 462–46
- - Warsia,M,F., N.S., Muhammad, Sarwarb I., Philips O. Agboolac P.O., Imran Shakird I., Sonia Zulfiqare, S. A, Comparative study on photocatalytic activities of various transition metal oxides nanoparticles synthesized by wet chemical route, Desalination and Water Treatment,2021,211 181–195.
- - Diaz,C., Segovia,M., Valenzuela, M.L. Solid State Nanostructured Metal Oxides as Photocatalysts and Their Application in Pollutant Degradation: A Review, Photochem. 2022, 2, 609–627.
- - Yadav S., Shakya K., Gupta A., Singh D., Chandran A.R., Aanappalli A.V., Kanika Goyal K., Rani N. Saini K. Review on degradation of organic dyes by using metal oxide semiconductors, Environmental Science and Pollution Research, 2023, 30, 71912–71932
- Kumari H., Suman S.,· Rohit Ranga R., Surjeet Chahal S., Seema Devi S., Sourabh Sharma S., Sandeep Kumar S., Kumar P., Suresh Kumar K., Ashok Kumar A., Rajesh Parmar R., Review on Photocatalysis Used For Wastewater Treatment: Dye Degradation, Water Air Soil Pollut , 2023 234,349.
- - Tong, H.; Ouyang, S.; Bi, Y.; Umezawa, N.; Oshikiri, M.; Ye, J. Nano-photocatalytic materials: Possibilities and challenges. Adv. Mater. 2012, 24, 229–251.
- Zhao, X.; Lv, L.; Pan, B.; Zhang, W.; Zhang, S.; Zhang, Q. Polymer-supported nanocomposites for environmental application: A review. Chem. Eng. J. 2011, 170, 381–394.
- Mauter, M.; Elimelech, M. Environmental applications of carbon-based nanomaterials. Environ. Sci. Technol. 2008, 42, 5843–5859.
- Sharma, Y.C.; Srivastava, V.; Singh, V.K.; Kaul, S.N.; Weng, C.H. Nano-adsorbents for the removal of metallic pollutants from water and wastewater. Environ. Technol. 2009, 30, 583–609.
- Gui, X.; Wei, J.; Wang, K.; Cao, A.; Zhu, H.; Jia, Y.; Shu, Q.; Wu, D. Carbon nanotube sponges. Adv. Mater. 2010, 22, 617–621.
- Ng, L.Y.; Mohammad, A.W.; Leo, C.P.; Hilal, N. Polymeric membranes incorporated with metal/metal oxide nanoparticles: A comprehensive review. Desalination 2013, 308, 15–33.
- - Khan I., Saeed K., Zekker I., Zhang B., Hendi A.H., Ahmad A., Ahmad S., Zada N., Ahmad H., Luqman Ali Shah L.A., Shah T., Khan I., Review on Methylene Blue: Its Properties, Uses, Toxicity and Photodegradation, Water 2022, 14, 242.
- -Allende P, Laguna M.A, Barrientos L, Valenzuela M.L, Diaz C. Solid State Tuning Morphology, Crystal Phase and Size through Metal Macromolecular Complexes and Its Significance in the Photocatalytic Response, ACS Applied Energy and Materials 2018, 1, 3159-3170.
- - Diaz C, Valenzuela M.L, Cifuentes‑Vaca O, Segovia M, Laguna‑Bercero M.A. Incorporation of Nanostructured ReO3 in Silica Matrix and Their Activity Toward Photodegradation of Blue Methylene. Journal of Inorganic and Organometallic Polymers and Materials 2020, 30, 1726–1734.
- Diaz C, Valenzuela M.L, Cifuentes‑Vaca O, Segovia M, Laguna‑Bercero M.A. Iridium nanostructured metal oxide, its inclusion in Silica matrix and their activity toward Photodegradation of Methylene Blue. Materials Chemistry and Physics 2020, 252, 123276-123286
- Diaz C, Valenzuela M.L, Cifuentes‑Vaca O, Segovia M. Polymer precursors effect in the macromolecular metal-polymer on the Rh/RhO2/Rh2O3 phase using solvent-less synthesis and its photocatalytic activity. Journal of Inorganic and Organometallic Polymers and Materials 2020, 30, 4702-4708.
- - Diaz C, Valenzuela M.L, Cifuentes‑Vaca O, Segovia M, Laguna‑Bercero M.A. Incorporation of NiO into SiO2, TiO2, Al2O3, and Na4.2Ca2.8(Si6O18) Matrices, Medium Effect on the Optical Properties and Catalytic Degradation of Methylene Blue, Nanomaterials 2020, 10, 2470-2487.
- Diaz C, Valenzuela M.L, Laguna-Bercero M.A, Mendoza K, Cartes P. Solventless preparation of thoria, their inclusion inside SiO2 and TiO2, their luminescent properties and their photocatalytic behavior. ACS Omega 2021, 6, 14, 9391–9400.
- - Gaya,U.I, Abdullah A.H., Heterogeneous photocatalytic degradation of organic contaminants over titanium dioxide: A review of fundamentals, progress and problems J. Photochem. Photobiol. C. 2008, 9, 1-12.
- - Joshi N.C.,Gururani P., Gairola S.P, Metal Oxide Nanoparticles and their Nanocompositebased Materials as Photocatalysts in the Degradation of Dyes,Biointerface Research in Applied Chemistry 2022,12, 6557-6579.
- - Kusuma K.B. , Manju M,* , Ravikumar C.R. , Raghavendra N. , Amulya S., Nagaswarupa H.P., Ananda Murthy H.C., M.R. Kumar A., Shashi Shekhar T.R. , Photocatalytic degradation of Methylene Blue and electrochemical sensing of paracetamol using Cerium oxide nanoparticles synthesized via sonochemical route, Applied Surface Science Advances 2022, 11,100304.
- - Pouretedal H.R. ,*, Kadkhodaie A., Synthetic CeO2 Nanoparticle Catalysis of Methylene Blue Photodegradation: Kinetics and Mechanism, Chin. J. Catal, 2010, 31, 1328–1334.
- - Saravanan R., Gupta V.K., Narayanan V. , Stephen A., Comparative study on photocatalytic activity of ZnO prepared by different methods, Journal of Molecular Liquids 2013, 181, 133–141.
- - Riapanitra A., Riyani K., Setyaningtyas T., Photocatalytic and Kinetics Study of Copper Oxide on the Degradation of Methylene Blue Dye, Advances in Physics Research, 2022, 5, 1-5.
- - Deka P., Deka R.C., Bharali P., Porous CuO nanostructure as a reusable catalyst for oxidative degradation of organic water pollutants ,New J. Chem., 2016, 40, 348—357.
- -Meshram S.P., Adhyapak P.V., Mulik U.P., Amalnerkar D.P. , Facile synthesis of CuO nanomorphs and their morphology dependent sunlight driven photocatalytic properties , Chemical Engineering Journal,2012, 204–206, 158–168.
- - Diaz, C.; Valenzuela, M.L.; Cifuentes-Vaca, O.; Segovia, M.; Laguna-Bercero, M.A. Incorporation of NiO into SiO2 , TiO2 , Al2O3 , and Na4.2Ca2.8(Si6O18) Matrices, Medium Effect on the Optical Properties and Catalytic Degradation of Methylene Blue. Nanomaterials 2020, 10, 2470.
- -Khairnar S.D., Shrivastava V., Facile synthesis of nickel oxide nanoparticles for the degradation of Methylene blue and Rhodamine B dye: a comparative study, Journal of Taibah University for Science, 2019, 13:1, 1108-1118.
- - Diaz, C.; Barrera, G.; Segovia, M.; Valenzuela, M.L.; Osiak, M.; O’Dwyer, C. Solvent-less method for efficient photocatalytic -Fe2O3 nanoparticles for using macromolecular polymeric precursors”. New J. Chem. 2016, 40, 6768-6776.
- -Khalaji A.D., Spherical α-Fe2O3 Nanoparticles: Synthesis and Characterization and Its Photocatalytic Degradation of Methyl Orange and Methylene Blue, Spherical α-Fe2O3 Nanoparticles: Synthesis and Characterization and Its Photocatalytic Degradation of Methyl Orange and Methylene Blue, Phys. Chem. Res., 2022, 10, 473-483.
- - Lassoued A., Mohamed Saber Lassoued M.S., Brahim Dkhil B., Ammar S.,Abdellatif Gadri,S., Photocatalytic degradation of methylene blue dye by iron oxide (α-Fe2O3) nanoparticles under visible irradiation, Journal of Materials Science: Materials in Electronics ,2018, 29,8142–8152.
- - Liu J., Wang B., Li Z., Wu Z., Kongjun Zhu, Zhuang J., Xi Q., Hou Y., Jiankang Chen J., Cong M., Li J., ,Qian G., Lin, Z., Photo-Fenton reaction and H2O2 enhanced photocatalytic activity of a-Fe2O3 nanoparticles obtained by a simple decomposition route, Journal of Alloys and Compounds 2019 771,398-405.
- - Quinteros E., Eder Lugo Medina E.L., Quevedo R.V., Garrafa H.E., Baez Y.A., Vargas F.A., Rafael Vilchis A.R, Luque P.A., A Study of the Optical and Structural Properties of SnO2 Nanoparticles Synthesized with Tilia cordata Applied in Methylene Blue Degradation, Symmetry 2022, 14, 2231.
- - Sadeghzadeh-Attar A., Efficient photocatalytic degradation of methylene blue dye by SnO2 nanotubes synthesized at different calcination temperaturas, Solar Energy Materials and Solar Cells 2018,183 ,16–24,
- -Kima S.P., , Choib M.Y., Choia H.C., Photocatalytic activity of SnO2 nanoparticles in methylene blue degradation, Materials Research Bulletin 2016,74, 85–89
- - Warang T., Patel N., Fernandes R., Bazzanella N., MiotelloA., , Co3O4 nanoparticles assembled coatings synthesized by different techniques for photo-degradation of methylene blue dye, , Applied Catalysis B: Environmental 2013, 132–133 204–211.
- - Bazgir S., Farhadi S., Microwave-assisted rapid synthesis of Co3O4 nanorods from CoC2O4 .2H2 O nanorods and its application in photocatalytic degradation of methylene blue under visible light irradiation, Int. J. Nano Dimens. 2017, 8, 284-297.
- - Zhang W., Yang Z., Wang X., Zhang Y., Wen X., Shihe Yang b, Large-scale synthesis of b-MnO2 nanorods and their rapid and efficient catalytic oxidation of methylene blue dye, Catalysis Communications 2006, 7, 408-412.
- - Cotton, F.A.; Wilkinson, G. Advanced Inorganic Chemistry; John Wiley and Sons: New York, NY, USA, 1980; Chapters 22 and 30. 64.
- - Jin, R. The impacts of nanotechnology on catalysis by precious metal nanoparticles. Nanotechnol. Rev. 2012, 31–56.
- - Fernandez-Garcia, M.; Martinez-Arias, A.; Hanson, J.; Rodriguez, C. Nanostructured Oxides in Chemistry: Characterization and Properties. Chem. Rev. 2004, 104, 4063–4104.
- - Zhao, Y.; Hernandez, E.A.; Vargas-Barbosa, N.M.; Dysart, J.L.; Mallouk, T.E. A high yield Synthesis of ligand-free iridium oxide nanoparticles with high electrocatalytic activity. J. Phys. Chem. Lett. 2011, 2, 402–406.
- - Biswas, K.; Rao, C.N. Synthesis and Characterization of Nanocrystals of the Oxide Metals, RuO2 IrO2, and ReO3 . J. Nanosci. Nanotechniol 2007, 7, 1969–1974.
- -Díaz, C.; Valenzuela, M.L. Metallic Nanostructures Using Oligo and Polyphosphazenes as Template or Stabilizer in Solid State. In Encyclopedia of Nanoscience and Nanotechnology; Nalwa, H.S., Ed.; American Scientific Publishers: Valencia, CA, USA, 2010; Volume 16, pp. 239–256.
- - Díaz, C.; Valenzuela, M.L. Macromolecular Complexes MXn Polymer as solid state precursors of metal and metal oxides nanostructures. In Book of CRC Concise Encyclopedia of Nanotechnology; Kharisov, B.I., Kharisov, O.V., Mendez, U., Eds.; CRC Press: Boca Raton, FL, USA, 2016; Chapter 42; pp. 504–524.
- - Díaz, C.; Valenzuela, M.L. Small-Molecule and High-Polymeric Phosphazenes containing oxypyridine side groups and their organometallic derivatives; Useful precursors for metal nanostructured materials. Macromolecules 2006, 39, 103–111.
- Díaz, C.; Valenzuela, M.L. Organometallic Derivatives of Polyphosphazenes as Precursors for Metallic Nanostructured Materials. J. Inorg. Organomet. Polym. Mater. 2006, 16, 419–435.
- Díaz, C.; Valenzuela, M.L.; Zuñiga, L.; O’Dwyer, C. Organometallic derivatives of cyclotriphosphazene as precursors of Nanostructured metallic materials: A new solid state Method. J. Inorg. Organomet. Polym. Mater. 2009, 19, 507–520
- Díaz, C.; Valenzuela, M.L.; Lavayen, V.; O’Dwyer, C. Layered Graphitic Carbon Host Formation during Liquid-free Solid State Growth of Metal Pyrophosphates. Inorganic Chem. 2012, 51, 6228–6236.
- Díaz, C.; Valenzuela, M.L.; Cáceres, S.; O´Dwyer, C. Solution and surfactant-free growth of supported high index facet SERS active nanoparticles of rhenium by phase demixing. J. Mater. Chem. A 2013, 1, 1566–1572.
- - Díaz, C.; Valenzuela, M.L.; Cáceres, S.; O´Dwyer, C.; Diaz, R. Solvent and stabilizer free growth of Ag and Pd nanoparticles using Metallic salts/cyclotriphosphazenes mixtures. Mater. Chem. Phys. 2013, 143, 124–132.
- Díaz, C.; Valenzuela, M.L.; Zuñiga, L.; O’Dwyer, C. Solid State Pathways to Complex Shape Evolution and Tunable Porosity During Metallic Crystal Growth. Sci. Rep. 2013, 2642, 1–8.
- Díaz, C.; Valenzuela, M.L. Nanostructures: Properties: Production Methods and Application. In Organometallic-Metallic Cyclotriphosphazene Mixtures: Solid-State Method for Metallic Nanoparticle Growth; Nova Science Publishers: New York, NY, USA, 2013; Chapter 5.
- Díaz, C.; Valenzuela, M.L. A General Solid-State Approach to Metallic, Metal Oxides and Phosphates Nanoparticles in Advances in Chemical Research; Nova Science Publishers: New York, NY, USA, 2011.
- Díaz, C.; Valenzuela, M.L. A general Solid-State approach to Metallic, Metal oxides and Phosphate nanoparticles Gold Nanoparticles: Properties Synthesis and Fabrication. In Solution and Solid State Methods to Prepare Au Nanoparticles: A comparison Chow PE; Nova Science Publishers: New York, NY, USA, 2010; Chapter 14.
- Díaz, C.; Valenzuela, M.L.; Lavayen, V.; Mendoza, K.; Peña, O.; O’Dwyer, C. Nanostructured copper oxides and phosphates from a new solid-state route. Inorg. Chim. Acta 2011, 377, 5–11.
- Díaz, C.; Platoni, S.; Molina, A.; Valenzuela, M.L.; Geaney, H.; O’Dwyer, C. Novel Solid-State Route to Nanostructured Tin, Zinc and Cerium Oxides as Potential Materials for Sensors. J. Nanosci. Nanotechnol 2014, 14, 7648–7675.
- Díaz, C.; Valenzuela, M.L.; Laguna, M.A.; Orera, A.; Bobadilla, D.; Abarca, S.; Peña, O. Synthesis and Magnetic Properties of Nanostructured metallic Co, Mn and Ni oxide materials obtained from solid-state macromolecular complex precursors. RSC Adv.2017, 7, 27729–27736.
- Díaz, C.; Valenzuela, M.L.; Bobadilla, D.; Laguna-Bercero, M.A. Bimetallic Au//Ag Alloys Inside SiO2 using a solid-state method.J. Clust. Chem. 2017, 28, 2809–2815.
- Díaz, C.; Valenzuela, M.L.; Garcia, C.; De la Campa, R.; Soto, A.-P. Solid-state synthesis of pure and doped lanthanides oxide nanomaterials by using polymer templates. Study of their luminescent properties. Mater. Lett. 2017, 209, 111–114.
- Díaz, C.; Valenzuela, M.L.; Segovia, M.; De la Campa, R.; Soto, A.-P. Solution, Solid-State Two Step Synthesis and Optical Properties of ZnO and SnO2 Nanoparticles and Their Nanocomposites with SiO2. J. Clust. Sci. 2018, 29, 251–266.
- Díaz, C.; Carrillo, D.; De la Campa, R.; Soto, A.-P.; Valenzuela, M.L. Solid-State synthesis of LnOCl/Ln2O3 (Ln = Eu, Nd) by using chitosan and PS-co-P4VP as polymeric supports. J. Rare Earth 2018, 36, 1326–1332.